Concrete floor installation in Tinton Falls NJ - a floor ready for what goes on top
Cracked, uneven basement floor, or a new room with bare ground? We pour a flat, solid slab that's ready for your flooring.
Request an estimate
What goes into a new concrete floor in Tinton Falls?
Concrete floor installation in Tinton Falls means we pour a slab over a vapor sheet that blocks ground moisture, then finish it, cut the joints and let it cure, so you end up with a hard floor that protects the tile, wood or carpet you lay on it later.
Most floor calls are a basement slab that's cracked and uneven, a garage floor being turned into a room, or an addition sitting on bare dirt. The first thing I ask is what's going on top, because the vapor sheet does the most for your flooring when the concrete goes right on it. Price moves with the size of the floor, how much old concrete has to come out, how far we wheel the mix from the truck and what the floor needs underneath. The schedule mostly turns on borough approvals and getting the old floor out, and the written estimate puts your own figure and plan on paper.
How we handle concrete floor installation
It starts with one question, what's going on top, because tile, wood, carpet or a coating decides how we lay the vapor sheet. We dig out and pack the subgrade, the dirt and stone the slab sits on, so the floor has something solid under it instead of loose fill. Then we roll out the sheet and keep boots off it, since even a small tear can let moisture up through the slab, and set any rebar, the steel bars that hold a slab together, the floor calls for. We pour, finish the top when the concrete is ready for it, cut the joints that give shrinkage cracks a planned place to go, and let it cure, which is the wait while the concrete gains strength before anything heavy rolls across it. If the budget gets tight, the base is the last thing I'd cut, because nobody sees it on day one and everybody sees it when the floor starts to sink.
Floors are one part of what we pour. If the new floor changes the height at a door that needs concrete steps, we can form them while we're there, and out back we build concrete pool decks with the same attention to what's underneath.
Concrete floor installation and the rules in Tinton Falls
Nobody can tell you from the paperwork alone whether your floor needs a permit, so we ask before we start. In Tinton Falls, the borough's Construction Official issues permits to build, alter or renovate a structure, and the borough's list names additions and renovations but not concrete floors. The state code, for its part, treats putting in or replacing flooring with a new material as ordinary maintenance that needs no permit, and neither one tells you for sure how your job is treated. The borough's Building Department asks owners to check with it, and that's where the answer comes from. Some jobs need more than one permit, and a building permit comes only after zoning or other approvals, so we sort out the order early, help you gather the survey and drawings and handle the filing with you.
If you're putting in a new slab, ask the borough too whether Tinton Falls is rated Tier 1 for radon, because the state's environmental protection department says new construction in Tier 1 places has to use radon-resistant methods, and once a place gets that rating it keeps it. Most of our floor calls are basements, garages and additions, and we do the same work on jobs in Eatontown and Red Bank.
- Call (732) 532-0238
- Mon–Fri: 7 AM–11 PM, Sat–Sun: 8 AM–10 PM
- Tinton Falls, NJ 07724
What happens when you call Tinton Falls Concrete in Tinton Falls?
Call or send the form
Tell us the size of the floor, what room it's in and the flooring you have in mind. We get back to you by phone or email, whichever way you reached us.
I measure and look it over
I check what's coming out, how we'll get concrete in and what's going on top, then put it all in a written estimate. You see the plan for the base, the sheet and the reinforcement right next to the price.
We line up the paperwork
If the borough needs permits or approvals, we work through them with you first. Once that's cleared, we pick a pour date.
We pour and walk it
My crew preps, forms and pours with me there running it. Before we pack up, we walk the finished floor with you and go over how to treat it while it cures.
Why Tinton Falls homeowners call Tinton Falls Concrete for a new floor
The owner prices every job
I'm the one who comes out to look at your floor and put the estimate together, and I'm on site running the crew when we pour. The person who told you the plan is the one making sure it happens.
In business since 2013
I learned this trade hauling forms and pushing mud on a small crew, then started this business 13 years ago. That's long enough to know what a rushed finish looks like a year later.
Licensed and insured in New Jersey
New Jersey's consumer affairs office counts work on garages, finished basements and attached floor coverings as home improvement contracting, so a floor like yours falls under those rules. We're fully licensed and insured.
On a floor, the part that counts is under the concrete. Tell us about your floor and I'll come take a look.
Request an estimateGet a written estimate for your concrete floor
Send the form and we'll reply within one business day, by phone or email. I come out, measure, look the site over, ask about your plans and give you a free written estimate, with no obligation and no pressure to book.
- Fully licensed and insured.
- Phone
- (732) 532-0238
- Location
- Tinton Falls, NJ 07724
- Hours
- Mon–Fri: 7 AM–11 PM, Sat–Sun: 8 AM–10 PM
Questions about concrete floors in Tinton Falls
How much does concrete floor installation cost per square foot in Tinton Falls?
Installing a cement slab across the US usually costs about $10.50 to $12.50 per square foot, and that's a national figure, not our price. Your floor can land above or below it depending on how much old concrete comes out, how far we carry the mix and what goes under it. The written estimate gives you your own number.
Do I need a permit for a new concrete floor in Tinton Falls, NJ?
It can, and the borough has the final say, so we check with its Building Department before we pour. A floor that's part of an addition or a renovation is the kind of job the borough's list names. If permits are needed, we handle the filing with you.
How do I keep moisture from ruining new flooring on a concrete slab?
Pour the concrete directly on a good vapor retarder, the sheet that blocks ground moisture, because the American Concrete Institute's floor guide says that's where it protects flooring and coatings most. Wet fill on top of the sheet holds water under the slab much longer, and the same guide says ordinary polyethylene sheeting shouldn't be counted on for this. Pouring right on the sheet takes extra care in the finishing, so we plan for it.
How do I keep a new concrete floor from cracking?
Cut the control joints on time, so the slab cracks along those saw lines instead of across the middle of the room. The institute's slab guide puts that window usually 4 to 12 hours after the pour, depending on the heat and the mix. Joints don't stop concrete from shrinking, they just decide where the crack shows up.
Should a concrete floor have fiber or steel reinforcement?
Use steel bars or welded wire if the floor needs added strength, because fibers mixed into the concrete reduce cracking but don't add structural reinforcement. All three are common on slabs. I'll tell you at the estimate which one your floor needs, and if fibers will do, I'll say so.
What causes a concrete floor to get dusty, flaky or uneven?
Bad timing on the finish usually causes it, because finishing, jointing and curing all have to happen when the concrete is ready, and getting that wrong can leave cracks, a dusty top, scaling or high and low spots. We plan each step before the truck shows up so nobody's guessing on pour day. It's a fair question to ask any crew you're thinking of hiring.
Other concrete work we do
Concrete pool decks
Putting in a pool? The deck around it needs a base that stays put and a surface that gives wet feet some grip.
Concrete steps construction
When a new floor changes the height at a door, new concrete steps can be formed to match so the rises come out even.
Get your concrete floor on the schedule
Have the floor size, the flooring you plan to lay and the kind of project ready when you call (732) 532-0238 or send the form, and the visit goes quicker.
Request an estimateCall (732) 532-0238